Detroit DDEC II Troubleshooting Diagnostic Manual CD ROM

Description: Detroit DDEC II Troubleshooting Diagnostic Manual CD ROM Product Specifics: Product title: MechanicStar - Detroit Diesel DDEC II Troubleshooting Manual CD-ROM [1988] Product description: This manual on disc provides instruction for troubleshooting the Detroit Electronic Controlled (DDEC) engines. Specifically covered in this manual are troubleshooting and repair steps that apply to DDEC II systems. 499 pages on disc. Product code: MS-MAN-DDECIITS Compatibility: Windows/Mac/Linux operating systems This manual on disc covers the following topics: SECTION 1. HOW TO USE THIS BOOK SECTION 2. BASIC KNOWLEDGE REQUIRED A. Electrical Circuits B. Use of Digital Volt-Ohm Meter C. Important Information .D. Explanation of Abbreviations/TermsE. General Diagnostic Information SECTION 3 . TESTING THE DDEC II SYSTEM A. Tools Needed to Diagnose the System B . Differences Between DDEC II and DDEC I C. Reading the Diagnostic Codes 1. Active vs . Historical Codes2. Using the " Check Engine" Light 3. Using the Diagnostic Data Reader D. Clearing Codes E. EEPROM Reprogramming F. Connector Checkout SECTION 4. TROUBLESHOOTING CHARTS A. The Diagnostic Procedure - Where to Start B. Diagnostic Codes - What They Mean C . Beginning ChartsStart First Chart for Diagnosis of DDEC II Using DDR CEL First Chart for Diagnosis of DDEC II When No DDR is AvailableD. Troubleshooting ChartsChart 1 Intermittent Code Or Symptom And No Codes Chart 2 Engine Cranks But Will Not StartChart 3 Poor Performance And No CodesChart 4 No "Check Engine" Light During Bulb CheckChart 5 " Check Engine " Light Always On And Code 25 On DDRChart 6 " Check Engine" Light Always On , No Data Link And Won 't Flash CodesChart 7 - No Data Link And Bulb Check OkayChart 8 - " Stop Engine" Light Always On And Code 25 On DDRChart 9 - No " Stop Engine " Light During Bulb Check Chart 1 0 - Stop Engine Override InoperativeChart 11 - Power Take-Off Speed Adjust InoperativeChart 12 - Cruise Control InoperativeChart 13 - " Cruise Active" Light Always OnChart 14 - "Cruise Active " Light Never OnChart 15 - Idle Shut-Down Feature Always On Chart 16 - Idle Shut-Down Feature Inoperative Chart 1 7 - Engine Brake Always Enabled Chart 18 - Engine Brake InoperativeChart 19 - Power Control Input Inoperative (Throttle Inhibit and Auxiliary Engine Protection)Chart 20 - Two Speed Governor Switch Inoperative Chart 21 - Throttle Inhibit Always On E. Diagnostic Code ChartsCode 11 - Power Take-Off Speed Adjust (PTOSA) Signal Voltage Low Code 12 - Power Take-Off Speed Adjust (PTOSA) Signal Voltage High Code 13 - Coolant Level Sensor (CLS) Signal Voltage Low Code 14 - Oil or Coolant Temperature Sensor (OTS or CTS) Signal Voltage High Code 1 5 - Oil or Coolant Temperature Sensor (OTS or CTS) Signal Voltage Low Code 16 - Coolant Level Sensor (CLS) Signal Voltage HighCode 21 - Throttle Position Sensor (TPS) Signal Voltage HighCode 22 - Throttle Position Sensor (TPS) Signal Voltage Low Code 23 - Fuel Temperature Sensor (FTS) Signal Voltage High Code 24 - Fuel Temperature Sensor (FTS) Signal Voltage Low Code 25 - No CodesCode 26 - Power Control Switch Code 31 - Fault On Auxiliary Output Code 32 - ECM Backup System Failure Code 33 - Turbo Boost Sensor (TBS) Signal Voltage High Code 34 - Turbo Boost Sensor (TBS) Signal Voltage Low Code 35 - Oil Pressure Sensor (OPS) Signal Voltage High Code 36 - Oil Pressure Sensor (OPS) Signal Voltage Low Code 41 - Timing Reference Sensor (TRS) Code 42 - Synchronous Reference Sensor (SRS) Code 43 - Low CoolantCode 44 - Oil or Coolant Overtemperature Code 45 - Low Oil PressureCode 46 - Low Battery VoltageCode 47 - Fuel Pressure Sensor (FPS) Signal Voltage High Code 48 - Fuel Pressure Sensor (FPS) Signal Voltage Low Code 51 - EEPROM ErrorCode 52 - ECM-Analog to Digital FailureCode 53 - EEPROM Failure Affecting Code Logging Code 54 - Vehicle Speed SensorCode 55 - Proprietary Communication Link Failure Code 56 - ECM - Analog to Digital FailureCode 58 - Cruise Control Switches Codes 6X (X= 1 to 8) - Injector Response Time Too Long Codes 7X (X= 1 to 8) - Injector Response Time Too Short Code 85 - Engine Overspeed ENG5V - Engine Harness + 5 Volt Supply VEH5V - Vehicle Harness + 5 Volt Supply Wiring DiagramsAbout MechanicStar MechanicStar provides professional service and repair software for on- and off-highway vehicles complete with OEM specifications, service & repair procedures, detailed illustrations and diagrams. Please feel free to message us with any questions.Shipping & Returns Item will ship within 2 business days. U.S. and Worldwide shipping available via USPS. Returns are not accepted for this item. We will gladly exchange any defective items in a timely manner.

Price: 29.99 USD

Location: Nashville, Tennessee

End Time: 2025-01-02T17:02:07.000Z

Shipping Cost: 10.45 USD